AD 2021-04-06 Describes The Unsafe Condition As A Missing Release Bar Retaining Screw On A Harley-Type Buckle Assembly
The FAA is adopting a new airworthiness directive (AD) for all Pilatus Aircraft Ltd. (Pilatus) Model PC-7 airplanes.
This AD results from mandatory continuing airworthiness information (MCAI) issued by the aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as a missing release bar retaining screw on a Harley-type buckle assembly installed on a harness shoulder strap. This condition, if not corrected, could lead to loss of pilot restraint and consequently loss of airplane control or injuries to the crew. The FAA is issuing this AD to address the unsafe condition on these products. This AD is effective February 12, 2021.
Supplementary Information: The Federal Office of Civil Aviation (FOCA), which is the aviation authority for Switzerland, has issued FOCA AD HB-2021-001-E, dated January 8, 2021 (referred to after this as “the MCAI”), to address the unsafe condition on Pilatus Model PC-7 airplanes.
The MCAI states:
An occurrence was reported where in an in service event a missing release bar retaining screw on a Harley-type buckle assembly installed on a harness shoulder strap on an ejection seat was detected.
This condition, if not corrected, could lead to loss of pilot restraint and consequently loss of aeroplane control or injuries to the crew.
To address this potential unsafe condition, Pilatus and IrvinGQ issued the [service bulletins] SBs to provide inspection instructions.
For the reason described above, this [FOCA] AD requires the inspection of the Harley-type buckle assemblies on the seat harnesses of the front and rear seats, as defined in this AD, and prohibits (re-) installation of affected parts.
FOCA advises that the release bar retaining screws on the affected Harley-type buckle assemblies were incorrectly peened during manufacture. This inadequate peening of the retaining screws has led to loose screws that can potentially be removed by hand or the actual screw falling out of the assemblies. You may examine the MCAI in the AD docket at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0049.
According To The Witness, Once The Airplane Landed, It Continued To Roll In A Relatively Straight Line Until It Impacted A Tree In His Front Yard On November 4, 2025, about 12:45 e>[...]
"In the frame-by-frame photos from the surveillance video, the left engine can be seen rotating upward from the wing, and as it detaches from the wing, a fire ignites that engulfs >[...]
Radar Required A term displayed on charts and approach plates and included in FDC NOTAMs to alert pilots that segments of either an instrument approach procedure or a route are not>[...]
From 2023 (YouTube Edition): It’s a Small World After All… Founded in 2011 by pilot, aircraft designer and builder, and U.S. Air Force veteran Sam Watrous, Uncasville,>[...]
Also: UFC Buys Tecnams, Emirates B777-9 Buy, Allegiant Pickets, F-22 And MQ-20 The NTSB's preliminary report on the UPS Flight 2976 crash has focused on the left engine pylon's sep>[...]
NTSB Prelim: Funk B85C
See All