Wed, Feb 13, 2019
Seven Events Of Premature Failure Reported To The Agency
The FAA has issued an SAIB related to the failure of the “Sensor-Oil Pressure (Hobbs Switch)”, part number (P/N) 83278 as it is referred to in the illustrated parts catalogue, installed in Textron Aviation Inc. (Textron) Model 172R, 172S, 182S, 182T, T182T, 206H, T206H airplanes. These engine oil pressure switches could have been provided new with the airplane or as a spares replacement part.
According to the FAA, the agency issued airworthiness directives (AD) in the past concerning these engine oil pressure switches for the above model airplanes. This engine oil pressure switch is currently the subject of AD 2013-11-11 which defines a life limit of 3000 hr. time in service (TIS). The existing AD remains in effect where applicable. However, the FAA is investigating recent events and may take additional AD action. The information and recommendations provided herein are intended to raise awareness of an issue that has a continued operational safety history, while our investigation continues.
The above-referenced engine oil pressure switch is used to drive the following:
- the red “OIL PRESS” warning annunciator on pre- Garmin G1000 airplanes, or
- the red “OIL PRESSURE” annunciation on the primary flight display of G1000 airplanes, and
- the airplane hour meter on all models above.
NOTE: the oil pressure gauge/indicator is driven by a separate dedicated pressure transducer.
The FAA is aware of seven events involving premature failure of this oil pressure switch, in which engine oil was found leaking from the pressure switch housing and/or found to have been pumped overboard, which can lead to obscuration of the windshield, limited forward visibility, loss of all engine oil and consequent engine failure.
In the SAIB, the FAA recommends the following:
- Be aware of this failure, which may be difficult to detect until after the fact, and pass this information along to any other applicable owner/operator or technician.
- Investigate any oil residue found on the forward fuselage upper cowling deck and/or windshield for root cause and take corrective action prior to further flight.
-
Inspect the oil pressure switch installation on the top rear or upper rear of the engine case, looking for:
- Oil seepage or staining around the oil pressure switch mount location
- Wet, moist or slippery oil pressure switch housing or wire leads
- Tool marks on the housing or any other indications of over-torque at installation
- Take corrective action and replace any oil pressure switch found with any of the above conditions before further flight per the applicable model Textron maintenance manual.
- Replace oil pressure switch P/N 83278 at 1000 hours TIS on any engine, per the applicable model Textron maintenance manual until further investigation has been conducted.
(Source: FAA)
More News
Say Altitude Used by ATC to ascertain an aircraft's specific altitude/flight level. When the aircraft is climbing or descending, the pilot should state the indicated altitude round>[...]
Aero Linx: European Air Law Association (EALA) EALA was established in 1988 with the aim to promote the study of European air law and to provide an open forum for those with an int>[...]
From 2023 (YouTube Version): The Life, Death, Life, Death, and Life of a Glorious Warbird In 1981, business-owner Jim Tobul and his father purchased a Chance-Vought F4U Corsair. Mo>[...]
Also: USCG Retires MH-65 Dolphins, Irish Aviation Authority, NATCA Warns FAA, Diamond DA42 AD This summer, history enthusiasts will have a unique opportunity to experience World Wa>[...]
Also: WACO Kitchen Bails, French SportPlane Mfr to FL, Dynon-Advance Flight Systems, Innovation Preview Bobby Bailey, a bit of a fixture in sport aviation circles for his work with>[...]