NTSB Final Report: North American T-28B | Aero-News Network
Aero-News Network
RSS icon RSS feed
podcast icon MP3 podcast
Subscribe Aero-News e-mail Newsletter Subscribe

Airborne Unlimited -- Most Recent Daily Episodes

Episode Date

Airborne-Monday

Airborne-Tuesday

Airborne-Wednesday Airborne-Thursday

Airborne-Friday

Airborne On YouTube

Airborne-Unlimited-06.17.24

Airborne-NextGen-06.18.24

Airborne-Unlimited-06.12.24 Airborne-FltTraining-06.13.24

Airborne-Unlimited-06.21.24

Sat, Mar 09, 2024

NTSB Final Report: North American T-28B

After Takeoff, With The Airplane About 200 Feet Above Ground Level (AGL), The Engine Sustained A Loss Of Power

Location: Fallbrook, California Accident Number: WPR22FA265
Date & Time: July 23, 2022, 13:31 Local Registration: N787AS
Aircraft: North American T-28B Aircraft Damage: Substantial
Defining Event: Fuel starvation Injuries: 1 Fatal, 1 Minor
Flight Conducted Under: Part 91: General aviation - Personal

Analysis: The pilot flew the airplane earlier in the day and made a stop at the accident airport. He performed a pre-flight inspection and positioned himself in the front seat, with the pilot-rated passenger in the rear seat. After takeoff, with the airplane about 200 feet above ground level (agl), the engine sustained a loss of power. The airplane collided with a plant nursery. 

The fuel system was designed where fuel flowed by gravity from all internal cells into the sump tank where an electric fuel boost pump was located. The airplane was also equipped with an engine-driven fuel pump. When the pilot turned the fuel “ON”, the electric fuel pump would simultaneously be turned on. An electric fuel-boost-pump test switch was in the cockpit and, as part of the start-up checklist, the switch had to be activated to momentarily interrupt power to the electric pump, allowing the pilot to confirm that the engine-driven fuel pump pressure is adequate (and that the electric fuel pump is operational). There was a 20-amp circuit breaker in series with the switch and the pump. If the electric pump fails below 10,000 feet pressure altitude, fuel drawn by the engine-driven pump is designed to bypass through the electric pump and sustain approximately normal fuel flow to the carburetor (with a slight drop in fuel pressure indication that may be noted).

Disassembly of the electric fuel pump revealed that metal shavings were lodged in the armature creating a short in the system. The blades on the impeller showed wear consistent with instability of the shaft during rotation. The upper commutator was cracked and showed wear on the upper portion. The pump-end bearing was worn on the outside with the labyrinth seal, washer, and shims deformed. The bearing cage was determined to be the metal pieces shorting out the armature.

Continuity was established from the electric pump test switch in the cockpit to the electric pump and to the circuit breaker. Attempts to trip the breaker were unsuccessful and further testing of the unit revealed it was functional. It could not be determined why the breaker did not trip when the electric pump shorted, but if the pilot had used the test switch, he likely would have been able to see the pump had failed.

A flow test of the carburetor revealed that numerous parameters were out of limits. At low power settings, the carburetor ran rich (more fuel flow than required for normal operation), and at high power settings the carburetor ran lean (less fuel flow than required for normal operation). Disassembly revealed that the enrichment valve’s diaphragm was stiff/rigid, consistent with it not being submerged in fuel for long durations. The carburetor manufacturer recommended that it should be overhauled at least every ten years and be pressurized regularly (if in a hot and dry climate, it should be done monthly). The internal diaphragms become brittle and can fail if they are not wetted with fuel regularly. The carburetor was overhauled over 12 years before the accident, equating to about 400 hours of flight time; during that time the pilot stated he had not completed any maintenance on it.

At takeoff power, the carburetor was not able to provide enough fuel to the engine because the enrichment diaphragm was brittle from inactivity. Additionally, because the electric fuel pump was inoperative, the fuel flow pressure was diminished providing less fuel to the carburetor. 

Probable Cause and Findings: The National Transportation Safety Board determines the probable cause(s) of this accident to be --  A loss of power due to an unmaintained carburetor diaphragm and inoperative electric fuel pump that resulted in fuel starvation to the engine. 

FMI: www.ntsb.gov

Advertisement

More News

Aero-TV: SUN 'n FUN Medical - Ready to Treat More Than Sunburns

The Medical Team of SNF Is Prepared For Just About Anything After a little medical incident of the Aero-News team, ANN Editor-in-Chief Jim Campbell stopped by the medical facility >[...]

ANN's Daily Aero-Linx (06.21.24)

Aero Linx: The Air Charter Safety Alliance The group, called the Air Charter Safety Alliance, will raise awareness of illegal charter flights among potential customers, charter bro>[...]

Aero-News: Quote of the Day (06.21.24)

“We’re getting set to host the biggest FlightSimExpo ever. See you for another unforgettable weekend of product launches, hands-on exhibits, educational seminars, re-co>[...]

ANN's Daily Aero-Term (06.21.24): Dead Reckoning

Dead Reckoning Dead reckoning, as applied to flying, is the navigation of an airplane solely by means of computations based on airspeed, course, heading, wind direction, and speed,>[...]

NTSB Prelim: Frost Dean C Rans S-12XL Airaile

(Witnessses) Reported That The Airplane Was Flying Close To The North Side Of The Peak And Subsequently Impacted The Ground About 81 Ft Below The Peak On June 8, 2024, about 0721 m>[...]

blog comments powered by Disqus



Advertisement

Advertisement

Podcasts

Advertisement

© 2007 - 2024 Web Development & Design by Pauli Systems, LC