Fri, Aug 02, 2013
Recombinant Gas Battery For LongRanger Helicopter
Concorde designed the RG-224, 24 Ah, RG Series (recombinant gas) helicopter battery to fulfill a demand for a higher capacity battery on the Bell LongRanger, and has received an overwhelming amount of positive feedback. Numerous LongRanger operators have converted to the RG-224, using Falcon Crest’s STC SR09069RC, to reduce engine wear and increase battery life.
High cyclic operations are hard on aircraft batteries due to frequent starts with short flight times. This style of operation shortens battery life because there is not enough time in flight for the battery to fully recharge. The two consequences of a partial charge are decreased capacity and shortened battery life.
When a battery is not fully recharged sulfate builds on battery plates. The sections of the plates covered with sulphate are inactive and the battery is unable to provide full cranking capacity on the next demanding start cycle. This decrease in capacity causes unnecessary wear on engine components. Air Ambulance and Oil & Gas fleets experience some of the highest cyclic operations. These operators have responded with surprise at the increased starting power and improved performance experienced after upgrading to the RG-224 packed with 42% more power than RG-222.
Aircraft batteries can be damaged beyond repair when they are discharged below 80% of their capacity. In high cyclic operations the capacity is slightly drained a little more on each start because a full charge is never achieved during a short flight. The higher capacity RG-224 provides more room for discharge before a full charge is required thereby extending battery life.
More News
Airport Marking Aids Markings used on runway and taxiway surfaces to identify a specific runway, a runway threshold, a centerline, a hold line, etc. A runway should be marked in ac>[...]
"It is extremely difficult, if not impossible, for manned aircraft to see a drone while conducting crop-enhancing and other aerial applications at low altitudes and high speeds. We>[...]
Aero Linx: The Skyhawk Association The Skyhawk Association is a non-profit organization founded by former Skyhawk Pilots which is open to anyone with an affinity for the A-4 Skyhaw>[...]
“The T-54A benefits from an active Beechcraft King Air assembly line in Wichita, Kansas, where all required METS avionics and interior modifications are installed on the line>[...]
Aero Linx: Aerostar Owners Association The Association offers the Aerostar Owner a unique opportunity to tap an invaluable source of information concerning the care and feeding of >[...]