Tue, Feb 05, 2013
Will Require The Inspection Of Stabilator Control Cables In Cherokee, Cherokee Six, Seneca, And Seminole Models
The FAA has published in the Federal Register an AD for Piper PA-28, PA-32, PA-34, and PA-44 airplanes. The FAA said AD was prompted by reports of control cable assembly failures that may lead to failure of the horizontal stabilator control system and could result in loss of pitch control.
The AD requires inspections of the stabilator control system and replacement of parts as necessary. We are issuing this AD to correct the unsafe condition on these products. In the discussion posted on the Federal Register Monday, the FAA said that according to NTSB Chair Deborah Hersman, two special airworthiness information bulletins (SAIBs) have been issued that recommend inspecting the entire surface of each cable terminal, turnbuckle, or other cable fittings for corrosion or cracking. Within the past 2 years, the NTSB has investigated two accidents and one incident involving Piper airplanes where control cable assembly failures due to stress corrosion cracking led to failures of the horizontal stabilator control system. She stated that the fact these events continue to occur more than 10 years after the SAIBs were issued shows that the SAIBs were not effective. The NTSB supports the need for this AD.
Piper investigated the possibility of using a commercial product called "scotch-brite" to remove surface corrosion and found it to be acceptable. The FAA said it will change this AD to reference the revised Piper Aircraft, Inc. Mandatory Service Bulletin No. 1245A, dated November 28, 2012, which incorporated cleaning agents and scotch-brite.
The inspection is expected to cost individual owners of the airplanes about $425 according to an estimate provided by the FAA. If it is determined that the stabilator control system needs to be replaced, that repair is estimated to cost the individual owner $1,458 in parts and labor.
The AD is effective March 11.
(Pictured above Piper Cherokee 6. Below (L-R) Piper Seneca, Cherokee, Seminole)
More News
Very High Frequency The frequency band between 30 and 300 MHz. Portions of this band, 108 to 118 MHz, are used for certain NAVAIDs; 118 to 136 MHz are used for civil air/ground voi>[...]
Aero Linx: Aviation Suppliers Association Established February 25, 1993, the Aviation Suppliers Association (ASA), based in Washington, D.C., is a not-for-profit association, repre>[...]
Have A Story That NEEDS To Be Featured On Aero-News? Here’s How To Submit A Story To Our Team Some of the greatest new stories ANN has ever covered have been submitted by our>[...]
From 2021 (YouTube Version): Colorado Campus Offers aVariety Of Aerospace Entertainment And Education Wings over the Rockies Exploration of Flight is the second location for the Wi>[...]
Also: Paramotor Champ's, Electric Ultralight, ICON BK Update, Burt Rutan at Oshkosh! The Popular Rotorcraft Association is reaching out for help in rebuilding their private runway >[...]
ANN's Daily Aero-Term (05.17.24): Very High Frequency
See All