NTSB Final Report: Champion 7ECA | Aero-News Network
Aero-News Network
RSS icon RSS feed
podcast icon MP3 podcast
Subscribe Aero-News e-mail Newsletter Subscribe

Airborne Unlimited -- Most Recent Daily Episodes

Episode Date

Airborne-Monday

Airborne-Tuesday

Airborne-Wednesday Airborne-Thursday

Airborne-Friday

Airborne On YouTube

Airborne-Unlimited-04.14.25

Airborne-NextGen-04.15.25

AirborneUnlimited-04.16.25

Airborne-AffordableFliers-04.17.25

SunnFun-DayFour-04.03.25

Wed, Dec 25, 2024

NTSB Final Report: Champion 7ECA

Postaccident Examination Of The Airplane Revealed The Left Wing Fuel Cap Was Missing, And Fuel Streaks Were Observed 

Location: Sussex, New Jersey Accident Number: ERA24LA359
Date & Time: August 27, 2024, 19:07 Local Registration: N9580S
Aircraft: Champion 7ECA Aircraft Damage: Substantial
Defining Event: Fuel exhaustion Injuries: 1 Minor
Flight Conducted Under: Part 91: General aviation - Personal

Analysis: The pilot was transporting the airplane from during a multi-leg trip and was on the second to last day of the trip. Prior to departure, he purchased fuel from a self-service pump and topped off both wing fuel tanks and checked that each fuel cap was properly secured. He calculated he had enough fuel for the 3.5 hour flight, plus a 40 to 50 minutes reserve, and departed. About 3 hrs. and 16 minutes into the flight, the engine lost total power. The pilot attempted to reach a nearby airport but made a forced landing about a mile short of the runway in trees, which resulted in substantial damage to the airplane’s right wing and tail section.

Postaccident examination of the airplane revealed the left wing fuel cap was missing, and fuel streaks were observed aft of the cap toward the trailing edge of the wing. The left wing fuel tank was intact and empty of fuel. The right wing fuel cap was secure, and the tank was absent of fuel. The pilot stated that he did not have any issues with the fuel cap properly securing prior to the accident flight. The left fuel cap was never located. Based on available information, it is likely that the cap was not properly installed, and that it separated from the airplane at some point during the flight. Fuel was subsequently siphoned from the tank(s), and as a result, the engine lost power sooner than the pilot calculated due to fuel exhaustion.

Probable Cause and Findings: The National Transportation Safety Board determines the probable cause(s) of this accident to be -- The pilot’s failure to properly secure the left wing fuel cap, which resulted in a total loss of engine power due to fuel exhaustion. 

FMI: www.ntsb.gov

Advertisement

More News

NTSB Prelim: AERO SP Z O O AT-4 LSA

According To A Witness, The Airplane Had Just Departed... When It Suddenly Descended And Struck The Ground At The End Of Runway 27 On March 22, 2025, about 0925 eastern daylight ti>[...]

ANN's Daily Aero-Linx (04.17.25)

Aero Linx: Alaska Airmen's Association At the Alaska Airmen's Association, we're more than just a community; we're a vibrant, passion-driven movement dedicated to safeguarding, pre>[...]

ANN's Daily Aero-Term (04.17.25): Taxi

Taxi The movement of an airplane under its own power on the surface of an airport (14 CFR section 135.100 [Note]). Also, it describes the surface movement of helicopters equipped w>[...]

Aero-News: Quote of the Day (04.17.25)

“I knew from the moment I watched him get shot down that we would have to go get him. I’m elated to be able to be here to see him be recognized and honored. He was the >[...]

Airborne Affordable Flyers 04.17.25: HKS Support Upgrade, Van's Tanks, eBristell

Also: 160-hp Carbon Cub UL, Flybox Avionics, Blackshape Aircraft, Scalebirds Update Light sport engine manufacturer HKS recently announced that it will be relocating its parts supp>[...]

blog comments powered by Disqus



Advertisement

Advertisement

Podcasts

Advertisement

© 2007 - 2025 Web Development & Design by Pauli Systems, LC