Fri, Jun 05, 2009
AD NUMBER: 2009-12-51
MANUFACTURER: Turbomeca
S.A. Arriel 1A1, 1A2, 1B, 1C, 1C1, 1C2, 1D, 1D1, 1E2, 1K1, 1S, and
1S1 turboshaft engine
SUBJECT: Airworthiness Directive 2009-12-51
SUMMARY: This emergency AD results from reports
of oil leaks from certain reduction gearbox (module M05) front
casings. The engine manufacturer reported that the lubrication duct
plug was not properly bonded/ glued in place. This condition, if
not corrected, could result in loss of the lubrication duct plug,
followed by a rapid draining of the oil tank, without indication to
the cockpit through low oil pressure warning. This condition can
lead to uncommanded in-flight engine shutdown, possible engine
fire, and an emergency autorotation landing.
Explanation of Relevant Service Information
We have reviewed Turbomeca S.A. Mandatory Service Bulletin (MSB)
No. A292 72 0825, Version A, dated May 27, 2009. The MSB identifies
the affected modules M05 by serial number, and describes procedures
for initial and repetitive visual inspections for oil leaks, and
repair of affected modules M05.
FAA’s Determination and Requirements of the
Rule
We have identified an unsafe condition that is likely to exist
or develop on other Turbomeca S.A. Arriel turboshaft engines of
this same type design. This AD requires initial and repetitive
visual inspections of affected modules M05 for oil leakage, repair
if leaking, and repair of all affected modules as terminating
action to the repetitive inspections. You must use the service
information described previously to perform these actions.
More News
Airport Marking Aids Markings used on runway and taxiway surfaces to identify a specific runway, a runway threshold, a centerline, a hold line, etc. A runway should be marked in ac>[...]
"It is extremely difficult, if not impossible, for manned aircraft to see a drone while conducting crop-enhancing and other aerial applications at low altitudes and high speeds. We>[...]
Aero Linx: The Skyhawk Association The Skyhawk Association is a non-profit organization founded by former Skyhawk Pilots which is open to anyone with an affinity for the A-4 Skyhaw>[...]
“The T-54A benefits from an active Beechcraft King Air assembly line in Wichita, Kansas, where all required METS avionics and interior modifications are installed on the line>[...]
Aero Linx: Aerostar Owners Association The Association offers the Aerostar Owner a unique opportunity to tap an invaluable source of information concerning the care and feeding of >[...]