Fri, Nov 23, 2007
Says Tape Permanently Solves R22, R44 Problem
Airwolf Aerospace LLC tells ANN the company was recently awarded
FAA STC# SR02491CH, to permanently prevent leading-edge skin
delamination from occurring on Robinson R22 and R44 helicopter main
rotor blades.
A factory Service Bulletin notes main rotor blade skins begin to
debond (separate) at the skin-to-spar bond line on the lower
surface near the blade tip. Debonding can occur when the bond line
is exposed due to excessive erosion of the blade finish, or when
corrosion occurs on the internal aluminum tip cap.
Robinson Helicopter Company has issued Service Bulletins to
inspect and address the problem using repeat-as-necessary paint
applied to the affected areas. By comparison, Airwolf tells ANN its
STC comprises a permanent, one-time application of Airwolf Rotor
Blade Protective Tape (RBPT) to the outer section of the main
rotorblades.
The one-time solution eliminates the need for blade repainting,
the company says.
"The factory 'solution' is really a band-aid, while ours is
simple and permanent," said Jonny Quest, Airwolf technical
director. "It comprises the application of a specially-formulated
adhesive polymer tape which has been time-tested by the military in
both the Gulf War and the Iraq war.
"Water, dust, sand and other contaminates can't penetrate the
tape, while the factory 'paint solution' requires repetitive
inspections and continual repainting throughout the blade life,"
Quest added. "However, the risk of a blade delamination is still
great and the replacement cost very expensive if this occurs. The
Airwolf RBPT is inexpensive insurance to prevent this from
happening."
There are over 8,000 Robinson helos on North American and
international registers.
More News
Takeoff Roll The process whereby an aircraft is aligned with the runway centerline and the aircraft is moving with the intent to take off. For helicopters, this pertains to the act>[...]
“We’re proud of the hard work that went into receiving this validation, and it will be a welcome relief to our customers in the European Union. We couldn’t be mor>[...]
"Aircraft Spruce is pleased to announce the acquisition of the parts distribution operations of Wag-Aero. Wag-Aero was founded in the 1960’s by Dick and Bobbie Wagner in the >[...]
IDENT Feature The special feature in the Air Traffic Control Radar Beacon System (ATCRBS) equipment. It is used to immediately distinguish one displayed beacon target from other be>[...]
Aero Linx: Pararescue Air Force Pararescuemen, also known as PJs, are the only DoD elite combat forces specifically organized, trained, equipped, and postured to conduct full spect>[...]