Fri, Sep 01, 2006
Finds Cracking In Rear Wing Spars of D-Model Regional
Aircraft
Acting on reports of cracks found in the wings of two Raytheon
(Beechcraft) 1900D regional turboprops, the FAA has issued an
emergency airworthiness directive calling for the immediate visual
inspection of the left and right wing rear spar lower caps for
cracking, and other damage.
During routine maintenance of two 1900D airliners, the wing rear
spar lower caps and rear spar web were found to have significant
cracks. The Raytheon Aircraft Company Structural Inspection Manual
requires a thorough inspection of the wing rear spar at 17,500
hours time-in-service (TIS) with repetitive inspections at
intervals of 3,000 hours TIS.
One airplane had 19,126 hours TIS when cracks were found. The
cracks were in the lower aft spar cap flange, but the cracks
extended upward into the web and terminated at the lightening hole
in the spar web. Fasteners were also found missing in the spar cap
and wing cove splice plate. There were no discrepancies recorded
from the initial inspection at 17,500 hours TIS on this
airplane.
Early indications show similar cracking on the other airplane.
The FAA continues to gather information on this airplane.
Analysis shows that similar cracks could also develop in the
wings of the Models 1900 and 1900C airplanes.
FAA’s Determination
After careful review of all available information related to the
subject presented above, we have identified an unsafe condition
that is likely to exist or develop on other products of this same
type design. For this reason, the FAA has determined that AD action
should be taken to detect and correct cracking in the wing rear
spar lower caps of the affected airplanes before the cracks grow to
failure. Such a wing failure could result in the wing separating
from the airplane with consequent loss of control.
AD Requirements
This AD requires the following:
- A one-time visual inspection of both the left and right wing
rear spar lower caps for cracking and other damage such as loose or
missing fasteners.
- Repair of any cracks or damage found.
- Report of any cracks or damage found to the FAA and RAC.
- Provisions are included in this emergency AD to position the
airplane to a home base, hangar, maintenance facility, etc. with
limitations.
This is considered interim action. The FAA will use the data
from the reporting requirement to determine what additional action
is necessary, which could result in future AD action.
More News
Aero Linx: Model Aeronautical Association of Australia MAAA clubs are about fun flying, camaraderie and community. For over 75 years, the MAAA has been Australia’s largest fl>[...]
Touchdown Zone Lighting Two rows of transverse light bars located symmetrically about the runway centerline normally at 100 foot intervals. The basic system extends 3,000 feet alon>[...]
“Discovery and innovation are central to our mission at Virgin Galactic. We’re excited to build on our successful record of facilitating scientific experiments in subor>[...]
How To Get A Story On Aero-TV News/Feature Programming How do I submit a story idea or lead to Aero-TV? If you would like to submit a story idea or lead, please contact Jim Campbel>[...]
Student Pilot Reported That During Rotation, “All Of A Sudden The Back Of The Plane Kicked To The Right..." Analysis: The student pilot reported that during rotation, “>[...]