Sat, Jul 10, 2021
AD 2021-13-03 Requires Repetitive Visual Inspections Of The Fuel Filter By-Pass Indicator Pop-Up
The FAA is adopting a new airworthiness directive (AD) for certain Safran Helicopter Engines, S.A. (Safran Helicopter Engines) Arriel 2B, 2B1, 2C, 2C1, 2C2, 2S1 and 2S2 model turboshaft engines. This AD was prompted by reports of non-conforming fuel filter pre-blockage pressure switches.
This AD requires repetitive visual inspections of the fuel filter by-pass indicator pop-up, a one-time operational test of the fuel filter pre-blockage pressure switch and, depending on the findings, replacement of the fuel filter pre-blockage pressure switch with a part eligible for installation. The FAA is issuing this AD to address the unsafe condition on these products. This AD is effective August 13, 2021.
Supplementary Information: The FAA issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 by adding an AD that would apply to certain Safran Helicopter Engines Arriel 2B, 2B1, 2C, 2C1, 2C2, 2S1 and 2S2 model turboshaft engines. The NPRM published in the Federal Register on February 22, 2021 (86 FR 10501). The NPRM was prompted by reports of non-conforming fuel filter pre-blockage pressure switches. In the NPRM, the FAA proposed to require repetitive visual inspections of the fuel filter by-pass indicator pop-up, a one-time operational test of the fuel filter pre-blockage pressure switch and, depending on the findings, replacement of the fuel filter pre-blockage pressure switch with a part eligible for installation. The FAA is issuing this AD to address the unsafe condition on these products.
The European Union Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued EASA AD 2019-0180, dated July 25, 2019 (referred to after this as “the MCAI”), to address the unsafe condition on these products. The MCAI states:
- Occurrences have been reported of non-conforming fuel filter pre-blockage pressure switches, manufactured before December 2016. The non-conformity of the fuel filter pre-blockage pressure switch can cause its non-activation in case of fuel system contamination, with consequent opening of the by-pass without indication in the cockpit.
- This condition, if not detected and corrected, and in case of fuel contamination, could lead to an uncommanded in-flight shut-down, possibly resulting in an emergency autorotation landing on a single engine helicopter, or to a double uncommanded in-flight shut-down on a twin engine helicopter.
- To address this potential unsafe condition, SAFRAN issued the MSB, providing inspection instructions.
- For the reasons described above, this [EASA AD] requires repetitive daily visual checks of the fuel filter by-pass indicator pop-up. This [EASA] AD also requires a one-time operational check of the affected part and, depending on findings, replacement of that part, which constitutes terminating action for the repetitive daily checks as required by this [EASA] AD.
You may obtain further information by examining the MCAI in the AD docket at https://www.regulations.gov by searching for and locating Docket No. FAA-2020-1180.
More News
With Testing Soon Complete, Launch Preparations Begin in Earnest Sierra Space's Dream Chaser has been put through the wringer at NASA's Glenn Armstrong Test Facility in Ohio, but w>[...]
Takeoff Roll The process whereby an aircraft is aligned with the runway centerline and the aircraft is moving with the intent to take off. For helicopters, this pertains to the act>[...]
“We’re proud of the hard work that went into receiving this validation, and it will be a welcome relief to our customers in the European Union. We couldn’t be mor>[...]
"Aircraft Spruce is pleased to announce the acquisition of the parts distribution operations of Wag-Aero. Wag-Aero was founded in the 1960’s by Dick and Bobbie Wagner in the >[...]
IDENT Feature The special feature in the Air Traffic Control Radar Beacon System (ATCRBS) equipment. It is used to immediately distinguish one displayed beacon target from other be>[...]