Tue, Feb 05, 2013
Will Require The Inspection Of Stabilator Control Cables In Cherokee, Cherokee Six, Seneca, And Seminole Models
The FAA has published in the Federal Register an AD for Piper PA-28, PA-32, PA-34, and PA-44 airplanes. The FAA said AD was prompted by reports of control cable assembly failures that may lead to failure of the horizontal stabilator control system and could result in loss of pitch control.
The AD requires inspections of the stabilator control system and replacement of parts as necessary. We are issuing this AD to correct the unsafe condition on these products. In the discussion posted on the Federal Register Monday, the FAA said that according to NTSB Chair Deborah Hersman, two special airworthiness information bulletins (SAIBs) have been issued that recommend inspecting the entire surface of each cable terminal, turnbuckle, or other cable fittings for corrosion or cracking. Within the past 2 years, the NTSB has investigated two accidents and one incident involving Piper airplanes where control cable assembly failures due to stress corrosion cracking led to failures of the horizontal stabilator control system. She stated that the fact these events continue to occur more than 10 years after the SAIBs were issued shows that the SAIBs were not effective. The NTSB supports the need for this AD.
Piper investigated the possibility of using a commercial product called "scotch-brite" to remove surface corrosion and found it to be acceptable. The FAA said it will change this AD to reference the revised Piper Aircraft, Inc. Mandatory Service Bulletin No. 1245A, dated November 28, 2012, which incorporated cleaning agents and scotch-brite.
The inspection is expected to cost individual owners of the airplanes about $425 according to an estimate provided by the FAA. If it is determined that the stabilator control system needs to be replaced, that repair is estimated to cost the individual owner $1,458 in parts and labor.
The AD is effective March 11.
(Pictured above Piper Cherokee 6. Below (L-R) Piper Seneca, Cherokee, Seminole)
More News
Inversion to Launch Reentry Vehicle Demonstrator Aboard SpaceX Falcon 9 This fall, the aerospace startup Inversion is set to launch its Ray reentry demonstrator capsule aboard Spac>[...]
"We are excited to accelerate the adoption of electric aviation technology and further our journey towards a sustainable future. The agreement with magniX underscores our commitmen>[...]
"The journey to this achievement started nearly a decade ago when a freshly commissioned Gentry, driven by a fascination with new technologies and a desire to contribute significan>[...]
Aero Linx: OX5 Aviation Pioneers Each year a national reunion of OX5 Aviation Pioneers is hosted by one of the Wings in the organization. The reunions attract much attention as man>[...]
"Our driven and innovative team of military and civilian Airmen delivers combat power daily, ensuring our nation is ready today and tomorrow." Source: General Duke Richardson, AFMC>[...]